Down Draft Paint Booth and Paint Mixing Room

JohnAbout Us, Collision, Custom Paint, Gallery, RestorationJanuary 2, 20140 Comment

Custom Paint at palm beach customs classic and muscle car restoration in florida

 

 Down Draft Paint Booth and Paint Mixing Room

This is my last spray booth install its a 28 ft by 14 ft Down Draft Bake Booth with 3 ” walls  it will ramp up to 165 degrees with a 1.5 million direct fired gas heater you can really speed up the drying cycle .Normally we paint @ 80 degrees and with a variable speed Freak drive on the exhaust side you are able to adjust the flow of air movement as the filters get dirty on the exhaust side the operator can speed up the motor allowing for positive pressure at all times to keep dust from entering the booth .

BOOTH 9

  •  This was in the build stage we were installing the tile floors for easy clean up and dust free paint jobs

 BOOTH 7

 

 

BOOTH 6

  • Below you can see the filter rack in the booth ceiling before the Spray booth filters were installed .
  • Note we poured concrete pad  for this booth 6 inches above grade to prevent water in the shop from rusting out the booth BOOTH 10
  •  The side walls just set in and clip together what a nice clean finish as you can see
  •  We built a 30ft long  paint mixing room with Tile floors so the painter was in a clean room to enter the booth during spray operation

  •  Here is another peek  of the  inside of the paint room where the painter has a bench to pre- mix for his job

 

 This was the far best investment I made for the booth its called a Chisum  air bag lift for painting it operates with a airbag so its safe for the spray booth environment it made painting full paint jobs a pleasure

As you can see here look how nice it is to tape off a cal and do the final prep procedures before paint

chiz3

below is a picture of the lift its stands as high as 1/2 a coke can and rolls around with a T handle  

hope you enjoyed the post on Down Draft Paint Booth and Paint Mixing Room

.
.
Get More Restoration Info

muscle car restoration shop in Florida
.
.

Latest Videos

Recent Posts

1969 Mustang 428 Cobra Jet Restoration in Florida

Back to Original, 1969 Mustang 428 Cobra Jet Restoration from Naples

September 6, 2017

Don Garlit's Drag Racing Museum in Ocala Florida

Don Garlit’s Drag Racing in Ocala Florida

July 29, 2017

muscle car restoration shop in florida

’67 Mustang Fastbacks @ Our Classic and Muscle Car Restoration Shop in Florida

July 25, 2017

Muscle Car Restoration Specialists in Florida

1970 Chevelle Muscle Car Restoration Specialists in Florida

July 24, 2017

Forest Green 1980 CJ5 Jeep Restoration from Bonita Springs Florida

July 15, 2017

This is One Awesome 1973 Bronco Restoration in Florida

July 11, 2017

Get a quote